major repairs is outlined in the POLARIS Service Manual and should be performed only by a SPORTSMAN / HO Owner’s Manual. P/N Sportsman HO Offroad Vehicle pdf manual download. Also for: Offroad Vehicle Polaris Sportsman EF Service Manual. Atv polaris This Official Polaris Sportsman And Sportsman And Hawkeye 2X4 Factory Service Manual provides detailed service information, step-by-step.
|Published (Last):||10 December 2006|
|PDF File Size:||16.30 Mb|
|ePub File Size:||1.43 Mb|
|Price:||Free* [*Free Regsitration Required]|
Safety You should review this information on a regular basis. Use caution when applying the auxiliary brake.
Wheel Removal Front Wheel Hub Tightening Front wheel bearing tightness and spindle nut retention are critical com- ponent operations. Record your vehicle’s identification numbers and key number in the spaces provided. Camber And Caster Follow the adjustment procedures exactly, or see your Polaris dealer for service.
Water in the bottom of the crankcase can lead to engine damage and mankal be drained. Ensure proper operation Ensure operation Ensure proper operation Inspect, clean Drain deposits whenever visible Check operation, apply Polaris dielec- tric grease when lamp is replaced Check operation, apply Polaris dielec- tric grease when lamp is replaced Wear approved helmet, goggles, and Disconnect the black negative battery cable first.
Page 30 The throttle lever is spring loaded. No clunky paper manuals without a search! The starter interlock will prevent the engine from starting if the transmission is in gear and the brake is not engaged. Number of bids and bid amounts may be slightly out of date. The throttle lever is spring loaded. Front Wheel Hub Tightening Front wheel bearing tightness and spindle nut retention are critical com- ponent operations. Always use Polaris-recommended spark plugs.
Nothing flashy, just all the information you need for a co mplete repair and or rebuild of your Polaris that you can view on your Battery Battery Installation Using a new battery that has not been fully charged can damage the bat- tery and result in a shorter life. Avoid operating the ATV through deep or fast-flowing water. Under normal operation, the diaphragm extends into the reservoir as fluid level drops.
Warranty or Service Bulletin repairs must be done by an authorized Polaris dealer. Page 70 Spark arrestor Idle speed Toe adjustment Headlight aim Perform these procedures more often for vehicles subjected to severe use. Engine speed returns to idle when the lever is released. In the event of product failure or defect, products are limited to the manufacturer warranty.
These brakes are self- adjusting. Avoid crossing the side of any hill unless absolutely necessary.
In addition to showing vehicle speed, the speedometer needle flashes when a warning condition exists. Do not dilute with water. Operation on Public Lands in the U. Always warm up the belt by operating below 30 mph for one mile 5 miles or more when temperature is below freezing. Lubricate the o-ring on the new filter with a film of fresh engine oil.
The transmission cannot be in reverse when using this feature. This means that the wheel on the outside of the turn must travel a greater distance than the inside wheel when turning and the inside tire must slip traction slightly.
Your safety is involved when these words and sym- bols are used.
Owner’s Manuals | Polaris
Look ahead and learn to read the terrain. Battery Installation Battery Battery Installation Using a new battery that has not been fully charged can damage the bat- tery and result in segvice shorter life.
Install the wheel nuts and finger-tighten them. Wear eye protection and leather work gloves. Avoid turning at sharp angles. The reverse override button is also the MODE button. Place shop towels beneath the oil filter.
Download ATV Quad Complete Service Shop Repair Manuals PDF
Add the recommended demand drive fluid as needed to bring the level to the bottom of the fill hole threads. Eye Protection Do not depend on eyeglasses or sunglasses for eye protection. Operation Break-In Period The break-in period for your new Polaris ATV is the first ten hours of operation, or the time it takes to use the first two full tanks of gasoline. Squeeze and release the brake lever two or three times, then pollaris and hold.
Take the vehicle to your dealer before starting the engine. Always follow these precautions when hauling cargo: Driving in Reverse Follow these precautions when operating in reverse: Polaris industries all terrain vehicle owner’s manual pages. Always change the oil filter whenever changing oil. Never operate the ATV with a spongy-feeling brake lever.